定制型凍干機乙醇甲醇混合溶液XY-GY-10FCIP超低溫深冷技術隔板小于-70度
General Detail 總述 | ||||
Sr. No. | Description 描述 | Specifications 規格 | ||
1 | Mode 型號 | XY-GY-10F (CIP) | ||
2 | Output (approx.) 產量（大約） | 40,500 units of vials 16mm diameter 外徑16毫米凍干瓶40,500瓶 | ||
21,500 units of vials 22mm diameter 外徑22毫米凍干瓶21,500瓶 | ||||
3 | Maximum ice capacity Z大捕冰力 | 200kg | ||
4 | Stoppering 壓塞 | Hydraulic stoppering 液壓壓塞（選配） | ||
5 | Control 控制方式 | Microprocessor 微機處理【無菌窒增加一套扳層升降操作系統】 | ||
6 | Dimension of unit (approx.) (L × W × H) (mm) (with hydraulic cylinder) 外型尺寸（大約）（長×寬×高）（帶液壓缸） | 5400 × 1650 × 3520 (Final dimension based on design) （以Z終設計尺寸為準） | ||
7 | Weight (approx.) 重量（大約） | 8,500kg | ||
Chamber 凍干箱 | ||||
1 | Chamber type 凍干箱外型 | Rectangular 長方體 | ||
2 | Sloping 箱體傾斜度 | 2% | ||
3 | Finish 內部拋光度 | Ra≤0.4um (0.4Mircon) | ||
4 | Corner 箱內角 | Coping 圓弧角 | ||
5 | Validation port 驗證孔 | Included 有（1個）位置箱體頂部 | ||
6 | Viewing port 視鏡 | Illuminated 帶遠射燈【LED廣角】 | ||
Number 數量 | 1 | |||
Location 位置 | Side 側面 | |||
Dimension 尺寸 | DN200 (mm) | |||
7 | Material 材質 | |||
Internal 內部 | AISI 304
| |||
Insulation 保溫 | Aluminum silicate and polyisocyanurate foam 硅酸鋁和聚氨酯發泡材料 | |||
External cover 外部 | 304 | |||
Door 箱門 | ||||
1 | Finish 拋光度 | Ra≤0.4um (0.4Mircon) | ||
2 | Viewing port 視鏡 | Included 有 | ||
Number 數量 | 1 | |||
4 | Open direction 開門方向 | 4 | cleaning water inlet valves 清洗水進口閥 | |
Brand 品牌 | Valbia | |||
Type 方式 | Butterfly 碟閥 | |||
5 | cleaning water outlet valves 清洗水出口閥 | |||
Brand 品牌 | Valbia | |||
Type 方式 | Butterfly 碟閥 | |||
Pipe welding 管道焊接 | 自動管-管軌跡焊接 | |||
Control System 控制系統 | ||||
1 | Software 軟件 | XY– 5000【可隨時免費升級】 | ||
Automatic 自動 | Included 有 | |||
Manual 手動 | Included 有 | |||
2 | PLC 可編程控制器 | Omron | ||
3 | Computer 電腦 | 聯想 | ||
4 | Touch screen 觸摸屏 | Omron | ||
5 | Vacuum gauge 真空探頭 | EDWARDS | ||
6 | Temperature probe 溫度探頭 | Pt100 | ||
7 | Breaker 空開 | schneider | ||
8 | Contactor 接觸器 | schneider | ||
9
| Relay 繼電器 | schneider | ||
Safety System 安全系統 | ||||
1 | Vacuum failure protection 真空失敗保護 | Included 有 | ||
2 | Temperature failure protection 溫度失敗保護 | Included 有 | ||
3 | Compressor protection 壓縮機保護 | Included 有 | ||
4 | Other motors protection 其它電機保護 | Included 有 | ||
5 | Interlock protection 連鎖保護 | Included 有 | ||
Utility Requirement (approx.) 共用工程消耗(大約) | ||||
1 | Electricity - total electrical load 總裝機功率 | 60kW (380V, 50Hz, 3Phase, 5Wire) | ||
2 | Cooling water for refrigerant cooling 用于制冷系統的冷卻水 | 20m3/hr (1.5≤P≤2bar, T≤25°C) | ||
3 | Water for injection for chamber cleaning 凍干箱純化水清洗 | 290L/min (P≥5bar, T=80°C) | ||
4 | Compressed air for pneumatic valves 用于氣動閥的壓縮空氣 | 50L/min (6≤P≤8bar) | ||
附件二：凍干機備品備件
序號 Serial number | 名稱 Name | 型號/規格/材質 Model/Specifications/Material | 數量 Number |
1 | 用于壓縮機的加液表套數 Set of manifold meter for compressor
| 1套 | |
2 | 冷凍機油 Refrigeration oil | BITZER | 5.0L |
3 | 電磁閥 Solenoid valve | DANFOSS | 2只 |
4 | 電磁閥線圈 Solenoid valve coil | DANFOSS | 2只 |
5 | 測溫探頭 Temperature probe | PT-100單支 | 2只 |
6 | 高壓壓力表 High-pressure gage | REFCO | 1個 |
7 | 低壓壓力表 Low-pressure gage | REFCO | 1個 |
8 | 干燥過濾器芯H48 Dry filter core | ALCO | 1個 |
9 | 干燥過濾器芯D48 Dry filter core | ALCO | 2個 |
10 | 真空泵油 Vacuum pump oil | EDWARDS | --- |
11 | 大門密封圈 | 硅橡膠 | 1根 |
12 | 干燥箱視鏡玻璃 Glass of chamber viewing port | DN-200 | 2塊 |
13 | 制冷專用板手 Special wrench for cooling | 1把 | |
14 | 視鏡密封圈 | 2根 | |
15 | 大油缸密封圈 Gasket for the bigger cylinder | 1套 |
環保在線